Consistency and mechanical properties of sustainable ...

2021-4-29 · as marble dust has been used in concrete production [5 ]. Quarry dust, fly ash and billet scale are successfully used in a study as cement replacement in a concrete mix [6]. Cementitious materials such as fly ash, rice hush ground granulated blast furnace slag, and bagasse ash can be used in concrete mix due to their pozzolanic properties [7].

Comparative Analysis of Engineering Properties of Indus ...

2021-4-20 · The quarry dust concrete and river sand concrete shoed slump test values of 80 mm and 60 mm, respectively. And, fresh concrete mix of quarry dust concrete showed lower workability than river sand concrete for 1:2:4 mix ratio and water-cement ratio of 0.55. The higher slump interposed for quarry dust may be due to higher sand content in quarry dust.

Effect of Quarry Dust on High Performance Concrete

2017-2-2 · usage of quarry dust as 60:40 proportion of substitution of natural sand i.e (quarry dust replaces 60% of natural sand) in concrete. Silica fume is added as mineral admixture by 15% of weight of cement and steel fiber used in different percentage (0.5%, 1.0%, and 1.5%) to …

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND …

2020-10-15 · in the production of concrete Quarry stone dust has many of the useful properties of the stone that it comes from. It is very heat resistant and poses the problem of acute shortage in many areas. Quarry rock dust can be an economic alternative to the river sand. Quarry Rock Dust as substitutes for Natural Sand in concrete.

Strength Characteristics of Quarry Dust in Replacement of …

2017-8-1 · Strength Characteristics of Quarry Dust in Replacement of Sand. K Shyam Prakash 1 and Ch Hanumantha Rao 2. Published under licence by IOP Publishing Ltd IOP Conference Series: Materials Science and Engineering, Volume 225, International Conference on Materials, Alloys and Experimental Mechanics (ICMAEM-2017) 3–4 July 2017, Narsimha Reddy Engineering College, India Citation K …

(PDF) Suitability of Quarry Dust as Partial Replacement ...

Method of curing by ponding was adopted and the compressive strength of quarry-dust-iron-filings-blended concrete with varying materials proportions of 12.5%, 25%, 37.5% …

An Explorative Study On Quarry Dust Blended Geo …

2019-11-20 · An Explorative Study On Quarry Dust Blended Geo Polymer Concrete For Various Concentrations Of Alkaline Activated Solution Cheveti Prathyusha1, M. Richard Ford2 1M.Tech: Structural Engineering Student, Lingayas Institute of Management and Technology, Madalavarigudem, Vijayawada, A.P., India.

Investigation of the Use of Quarry Dust as a Substitute of ...

2021-8-23 · This project report on "investigation of the use of quarry dust as a substitute of river sand in concrete mixes" contains figures, table of contents, nomenclature, slump test, data analysis and presentation, research methodology, the effect of shape and texture of fine aggregate, properties of concrete, concrete …

Study of Concrete Involving Use of Quarry dust as Partial ...

2015-3-9 · increase in quarry dust content. Quarry dust particles absorbed more water as compared to sand and thus negatively impacting the workability of concrete mix. Slump was minimum for the concrete mixture containing 40% quarry dust in place of fine aggregates. The variation of slump with quarry dust content is depicted in Fig. 3.

An Innovative Method of Replacing River Sand by Quarry ...

2016-9-9 · an attempt to partially replace quarry dust in place of sand in M35 grade concrete. On experimentation, it was found that the. partial replacement of sand . with. 10% of quarry du. st. has given. the optimum results. Therefore, t. his study recommends that. if. partial replacement of . sand with . quarry dust upto 10% . in M35 grade of concrete ...

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · Two grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to in step of 10%.

UTILIZATION OF WASTE QUARRY DUST AND MARBLE …

2019-7-10 · Sargodha, Sakhi Sarwar, Margalla sites which can be as partial alternative to sand in concrete. Research on use of waste marble powder and quarry dust in concrete is on the go worldwide. Priyatham, B. P. R. V. S. et al. (2017), found that compressive strength and split cylinder tensile strength increased when quarry dust was substituted for sand up

(PDF) Use of Quarry Dust to Replace Sand in Concrete – An ...

TESTING PROCEDURE Fine aggregate 28 days A. Fresh concrete workability Sand: Quarry dust Compressive strength ( in MPa) To determine consistency of concrete, Slump test was M20 M25 conducted with varying water content and a particular water 100:0 17.63 24.37 cement ratio (w/c) which gives the slump of 60mm was selected 90:10 18.29 24.50 from graph.

"A STUDY ON SELF COMPACTING CONCRETE …

2021-2-27 · levels for M40 grade concrete. The test results shows the Foundry sand, Quarry dust and Metakaolin can be used effectively to replace fine aggregate and Cement Respectively in concrete. Keyword : -Foundry sand, Quarry Dust, Metakaolin, SCC etc…. 1. INTRODUCTION The major problem of the word is facing today the environmental pollution.

EXPERIMENTAL INVESTIGATION ON HIGH STRENGTH …

2018-3-24 · Major objective of the study was to examine the suitability of M -sand and quarry dust is the partial replacement as fine aggregate in High strength concrete. Apart from characterizin g the properties of M -sand and quarry dust, tests were performed on the High strength concrete using M -sand and quarry dust [13]. 1.

COMPARING THE COMPRESSIVE STRENGTHS OF …

2018-9-14 · This work is focused on the use of quarry dust as a total replacement to river sand in the production of concrete, and comparing the results (compressive strength) to that obtained from conventional concrete made with river sand. Key word: Quarry dust, river sand, compressive strength, water cement ratio, workability. 1. INTRODUCTION

USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT …

2018-10-3 · 4. The physical and chemical properties of quarry dust satisfy the requirements of sand. 5. Use of quarry dust in concrete help in workability of concrete. 6. Quarry dust is a waste product from stone crushing industry and available almost free-of-cost, as partial replacement for river sand…

[PDF] Experimental Investigation on the Effect of ...

The demand of natural sand in the construction industry has increased a lot resulting in the reduction of sources and an increase in price. Thus an increased need to identify a suitable substitute, that is eco-friendly and inexpensive quarry dust being extensively used as an alternative to the sand in the production of concrete. In this paper an attempt has been made to determine the ...

(PDF) Study on Performance of Quarry Dust as Fine ...

2018-3-7 · The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%, …

Comparing the Compressive Strengths of Concrete Made …

Comparing the compressive strengths of concrete made with river sand and quarry dust as fine aggregates Chijioke Chiemela1, fgwegbe talter1, Ibearugbulem Ogedi1, Okoye meter2, Oke Mong2 1Civil Engineering Department, Federal Polytechnic Nekede, Owerri, Imo State, Nigeria 2Mechanical Engineering Department, Federal Polytechnic Nekede Owerri Imo State, Nigeria

The Utilization of Quarry Dust as Fine Aggregates in …

quarry dust, which is a waste product from quarry, as fine aggregates in traditional concrete. During the tenure of the study, some physical and engineering properties of quarry dust and sand …

Disqussion | COMPARATIVE ANALYSIS OF STRENGTH OF …

Scope of Study. This project work focuses on the comparative analysis of strength of concrete using sharp sand from the bed of Unwana river in Afikpo North L.G.A and quarry dust from Amasiri Quarry site in Afikpo south L.G.A. all in Ebonyi state. The concrete mix design used was 1:2:4 and unicem cement was also used in carrying out the ...

COMPRESSIVE AND TENSILE STRENGTH OF CONCRETE …

2019-4-21 · various combinations of lateritic sand and quarry dust as complete replacement for conventional river sand. The result is found better workability and high compressive strength [8 ] Concrete is the most commonly used material for construction and their design consumes almost the total cement production in the world.

(PDF) EFFECT OF QUARRY DUST AS PARTIAL …

quarry dust in concrete is desirable because of its benefits such as useful disposal of byproducts, reduction of river sand consumption as well as increasing the strength …

(PDF) USE OF QUARRY DUST AND IRON FILINGS IN …

the 37.5% and 50% quarry-dust-iron-filings-blended concrete and the conventional concrete and this actually justifies the use of the two would-be waste materia ls as sand replacements in concrete ...

USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT FOR NATURAL SAND

(PDF) Study on Performance of Quarry Dust as Fine Aggregate in …

Partial Replacement of Sand by Quarry Dust in Concrete

2021-6-4 · Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur . Abstract- The paper describe the role of quarry dust In the construction of buildings and other structures to eliminate the demand of natural sand by using quarry waste to replace the use of natural sand.